Recall Information

Description

Ford is recalling certain model year 1999-2003 windstar vehicles originally sold in or currently registered in the States of connecticut, delaware, the district of columbia, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, utah, vermont, west virginia, and wisconsin. A separation of a front lower control arm rear attaching bracket may result in a lower control arm separation. A separation of both front subframe rear body mounts may result in separation of the steering intermediate shaft.

Safety Risk

This could result in reduced steering control increasing the risk of a crash.

Remedy

Dealers will inspect both front lower control arm rear attaching brackets, and both body mount attachments at the rear of the front subframe, and make the necessary repairs free of charge.

Next Steps

Description

On your vehicle, localized overheating of the engine cylinder head may cause the cylinder head to crack, causing an oil leak that may result in a fire in the engine compartment NHTSA recall 13V-583.

Safety Risk

A fuel leak in the presence of an ignition source may result in a fire.

Remedy

Ford Motor Company has authorized your dealer to make repairs to address potential overheating that may result in a fire in the engine compartment, and to inspect the installation of the fuel line jumper and replace it if necessary. These enhancements and repairs will be completed free of charge parts and labor.

Next Steps

Description

Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 F-250 sd through F-550 sd diesel, 1992-2003 E-150 through E-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 F53 vehicles equipped with the texas instruments speed control deactivation switch (scds). The scds may leak internally and then overheat, smoke, or burn.

Safety Risk

A vehicle fire could occur with or without the engine running.

Remedy

Ford will notify owners that dealers will install a fused wiring harness in line with the scds. On 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the ABS control module connector and repair as necessary. Repairs will be completed free of charge. The safety recall began on October 27, 2009. Owners may contact Ford at 1-888-222-2751.

Next Steps

Description

Ford is recalling certain 1997 through 2003 model year Ford F-150, 2004 model year Ford F-150 heritage, 1997 through 1999 model year F-250 less than 8,500 lbs. Gross vehicle weight rating - gvwr, and 2002 and 2003 Lincoln blackwood vehicles manufactured from June 20, 1995, through August 4, 2004, originally sold, or currently registered in, connecticut, delaware, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the district of columbia. Prolonged exposure to road deicing chemicals may cause severe corrosion of the fuel tank straps which secure the tank to the vehicle.

Safety Risk

As a result of the corrosion, one or both straps may fail allowing the fuel lines to separate from the tank, or in some cases, causing the tank to contact the ground. Either scenario may result in a fuel leak presenting a fire hazard.

Remedy

Ford Motor Company has authorized your dealer to install either new fuel tank straps or a new fuel tank strap reinforcement kit. Both include additional corrosion protection and are provided free of charge parts and labor.

Next Steps

Description

Vehicle description: minivans built with instrument clusters without the message center, fail to comply with the requirements of standard no. 118, "power-operated window, partition, and roof panel systems." the power windows may be operable after the ignition has been turned to the "off" position and the front doors are opened.

Safety Risk

The standard requires that power operated windows may be closed only when the key is in the "on," "start," or "accessory" positions, or during the interval between the time the key is turned off, and the opening of either of the vehicle's front doors.

Remedy

Dealers will reconfigure the vehicle front end electronic module.

Next Steps

Description

Vehicle description: mini vans equipped with auxiliary rear air-conditioning. If the auxiliary air-conditioning blower Motor stops turning while in the medium-low blower speed setting, there is the potential that the resistor may become hot and smoke.

Safety Risk

The Motor could potentially catch on fire.

Remedy

Dealers will install a jumper wire that will ensure that the medium-low blower speed setting is protected by the thermal limiter. Owner notification began augsut 27, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Ford at 1-866-436-7332.

Next Steps

Description

In certain vehicles that had the recall service performed under either safety recall 10S13 NHTSA numbers 10V-385 and 12V-193 or 12S30 NHTSA number 12V-195, the brackets may have been misinstalled, potentially limiting the effectiveness of the recall service repair in addressing the safety defect. Ford has identified approximately 500 reports of brackets that were misinstalled as part of recall service under either safety recall 10S13 or 12S30. Also, at the request of NHTSA, Ford reviewed three crash vehicles and determined all three vehicles had misinstalled rear axle reinforcement brackets, but the root cause of the accidents was inconclusive.

Safety Risk

Safety recalls 10S13 and 12S30 were conducted to address the risk that the combined effects of corrosion and stress can lead to cracks which, if undetected, can propagate and result in a complete fracture of the axle. In addition, a misinstalled rear axle reinforcement bracket may limit the effectiveness of the recall repair to reduce the propensity for an axle fracture. A fractured rear axle may affect vehicle handling, increasing the risk of a crash.

Remedy

Ford Motor Company has authorized your dealer to inspect the rear axle reinforcement brackets that were previously installed. If the rear axle reinforcement brackets were installed improperly, your dealer will replace the rear axle free of charge parts and labor if necessary.

Next Steps

Description

Vehicle description: mini vans. Contaminants such as water, salt, and windshield washer solution can enter the wiper Motor cover assembly through pinholes on the exterior of the cover that are used in the molding process. In addition, on certain of the vehicles built between February and August 2000, a switch located in the plastic cover of the wiper Motor gear case could malfunction and overheat. Either of these conditions could potentially result in loss of intermittent wiper function, loss of wiper park function, complete loss of wiper function, smoke, or ignition of the plastic cover material. Contaminant entry could also result in unintended wiper Motor operation.

Safety Risk

Switch malfunction is most likely to occur when the intermittent setting of the wipers is being used, or when snow or ice obstructs the blades from returning to the "parked" position at the bottom of the windshield. Loss of visibility while driving increases the risk of a crash.

Remedy

Dealers will install a new wiper cover with improved sealing and water resistance. Owner notification begain August 27, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Ford at 1-866-436-7332.

Next Steps

Campaign:

69B01

Description

Dealer trade for fsa 11S16

Next Steps

Campaign:

79M01

Description

Windstar rear axle - rental claiming for 10S13

Next Steps

Campaign:

89M01

Description

Rental program for fsa 11S16

Next Steps

Campaign:

15N02

Description

Rear axle extended coverage

Next Steps