Recall Information

Description

On certain sport utility vehicles equipped with speed control and 4.0L sohc engines, if the strand cover on the speed control cable becomes flared at the end, the speed control cable may bind when the speed control is activated.

Safety Risk

The throttle return spring force may not be sufficient to overcome the binding condition when the speed control is disengaged. Braking function would be maintained though stopping distances may be increased.

Remedy

Dealers will inspect the speed control cable and, if necessary, replace it. Owner notification began August 29, 2003. Owners should contact Ford at 1-866-436-7332.

Next Steps

Description

Vehicle description: 4-DOOR sport utility vehicles equipped with side air bags. The subject vehicles have a revised level side crash sensor that could deploy the side air bag if the ignition key is in the "run" position and the seatbelt webbing is forcibly extracted from a locked retractor with a jerking motion.

Safety Risk

Inadvertent side air bag deployment could cause personal injury to the seat occupant.

Remedy

Dealers will replace the side crash sensors with a revised design that will reduce the likelihood of an unexpected side air bag deployment.

Next Steps

Description

On certain sport utility vehicles and pickup trucks, the speed control deactivation switch may overheat, smoke, or burn.

Safety Risk

This condition could lead to a fire. Fires have occurred while the vehicles were parked with the ignition 'off.'

Remedy

Ford Motor Company has authorized your dealer to perform the repairs under this program free of charge parts and labor. If you had the interim repair speed control system disconnect performed, the final repair will restore operation of the speed control system.

Next Steps

Description

Vehicle description: sport utility vehicles equipped with the 3.27 or 3.55 axle ration. The subject vehicles have a powertrain control module that could allow the vehicle to exceed the design intent top speed. At these extreme speeds, the vehicle could be capable of exceeding the speed rating of the tire.

Safety Risk

Operating the vehicle above the maximum speed rating could lead to a tire failure which at these speeds could result in a crash.

Remedy

Dealers will reprogram the powertrain control module.

Next Steps

Description

Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 F-250 sd through F-550 sd diesel, 1992-2003 E-150 through E-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 F53 vehicles equipped with the texas instruments speed control deactivation switch (scds). The scds may leak internally and then overheat, smoke, or burn.

Safety Risk

A vehicle fire could occur with or without the engine running.

Remedy

Ford will notify owners that dealers will install a fused wiring harness in line with the scds. On 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the ABS control module connector and repair as necessary. Repairs will be completed free of charge. The safety recall began on October 27, 2009. Owners may contact Ford at 1-888-222-2751.

Next Steps

Description

Ford is recalling certain model year 2013 explorer, taurus, flex, fusion, police interceptor sedan and police interceptor utility vehicles; and certain model year 2013 Lincoln mks, mkt, and mkz vehicles. In the affected vehicles, the fuel delivery module may develop a crack, allowing fuel to leak.

Safety Risk

A fuel leak in the presence of an ignition source may result in a fire.

Remedy

Ford Motor Company has authorized your dealer to replace the fuel delivery module free of charge parts and labor.

Next Steps

Description

Vehicle description: passenger vehicles, light duty trucks, sport utility vehicles, and mini vans equipped with trw seat belt buckle assemblies. The buckle base of these seat belt assemblies were not properly heat treated and therefore do not pass the load bearing requirement of federal Motor vehicle safety standard no. 209, "seat belt assemblies."

Safety Risk

In the event of a vehicle crash, the occupant may not be properly restrained.

Remedy

Dealers will inspect the date code on certain seat belt buckles of your vehicle and replace all seat belt buckles that fall within the suspect date code range. Owner notification began October 26, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Ford at 1-866-436-7332.

Next Steps

Description

On certain sport utility vehicles equipped with high back seats, the upper bolt on the driver's side high back seat, that attaches the seat recliner mechanism to the seat back frame, could fracture. If the bolt fractures and does not jam in the seat back frame, the seat back may recline until it makes contact with an object behind the seat, such as the second row seat cushion.

Safety Risk

The driver could potentially lose contact with the steering wheel or foot pedals during such an event, increasing the risk of a crash.

Remedy

Dealers will replace the driver seat upper bolt with a metal spacer and bolt. In addition, seats with tubular back frames will have the fully threaded lower recliner bolt replaced with a partially threaded bolt. Owner notification began on August 29, 2003. Owners should contact Ford at 1-866-436-7332.

Next Steps

Campaign:

99S28

Description

Fog lamp relay and jumper harness

Next Steps

Campaign:

00B40

Description

Multifunction switch

Next Steps