Recall Information

Description

Ford is recalling certain 1997 through 2003 model year Ford F-150, 2004 model year Ford F-150 heritage, 1997 through 1999 model year F-250 less than 8,500 lbs. Gross vehicle weight rating - gvwr, and 2002 and 2003 Lincoln blackwood vehicles manufactured from June 20, 1995, through August 4, 2004, originally sold, or currently registered in, connecticut, delaware, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the district of columbia. Prolonged exposure to road deicing chemicals may cause severe corrosion of the fuel tank straps which secure the tank to the vehicle.

Safety Risk

As a result of the corrosion, one or both straps may fail allowing the fuel lines to separate from the tank, or in some cases, causing the tank to contact the ground. Either scenario may result in a fuel leak presenting a fire hazard.

Remedy

Ford Motor Company has authorized your dealer to install either new fuel tank straps or a new fuel tank strap reinforcement kit. Both include additional corrosion protection and are provided free of charge parts and labor.

Next Steps

Description

Ford Motor Company (ford) is recalling certain model year 2001-2004 escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin and the district of columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.

Safety Risk

A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.

Remedy

Ford Motor Company has authorized your dealer to install a reinforcement crossbrace on the subframe so that steering control can be maintained in the event of a separation of the lower control arm forward attachment. This service will be performed free of charge parts and labor.

Next Steps

Description

On certain sport utility vehicles equipped with 3.0L V6 engines, during deceleration, the engine can stall.

Safety Risk

Should the engine stall, a vehicle crash could occur.

Remedy

Dealers will reprogram the power control module (pcm) with the appropriate calibration. Owner notification began on April 21, 2004. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Ford at 1-866-436-7332.

Next Steps

Description

Ford is recalling certain model year 2001-2002 escape vehicles manufactured from October 22, 1999, through July 19, 2002, equipped with a brake master cylinder reservoir cap that could leak brake fluid. If brake fluid leaks from the cap, it could come in contact with the antilock brake system - ABS module wiring harness connector.

Safety Risk

Corrosion can develop in the electrical connector leading to melting, smoke or a fire.

Remedy

Ford Motor Company has authorized your dealer to install a new redesigned master cylinder reservoir cap and a fused ABS relay. These repairs will be performed free of charge parts and labor.

Next Steps

Description

On your vehicle, localized overheating of the engine cylinder head may cause the cylinder head to crack, causing an oil leak that may result in a fire in the engine compartment NHTSA recall 13V-583.

Safety Risk

A fuel leak in the presence of an ignition source may result in a fire.

Remedy

Ford Motor Company has authorized your dealer to make repairs to address potential overheating that may result in a fire in the engine compartment, and to inspect the installation of the fuel line jumper and replace it if necessary. These enhancements and repairs will be completed free of charge parts and labor.

Next Steps

Description

Certain 2004-2005 sport utility vehicles and certain 2001-2003 sport utiity vehicle having rear liftgate components serviced with 2004 equivalent components fail to comply with the requirements of federal Motor vehicle safety standard no. 206, 'door locks and door retention components.' the rear liftgate latching system does not meet the inertia load requirement in one direction.

Safety Risk

If the liftgate is left unlocked, there is the potential that it may open during a crash.

Remedy

Dealers will replace the rear liftgate latch release rod, the release rod attachment clip and the door handle return spring. The recall began on March 31, 2005. Owners should contact Ford at 1-866-436-7332.

Next Steps

Description

On certain sport utility vehicles equipped with antilock brakes (ABS), the ABS module connector may have missing or dislodged wire seals. This condition could allow contamination to enter the module connector, creating a potential for an electrical short.

Safety Risk

An electrical short might cause an ABS malfunction that would illuminate the ABS warning light, and in some cases, the module may overheat resulting in burning odor, smoke, and/or fire. This condition could occur either when the vehicle ignition switch is in the off position or while the vehicle is being operated.

Remedy

Dealers will inspect the wire harness connector to the ABS module for missing or dislodged wire seals, and repair or replace the harness connector as appropriate. The dealer will also inspect the connector on the ABS module and replace it if it is found to be corroded or damaged. The recall began on April 23, 2007. Owners may contact Ford at 1-866-436-7332.

Next Steps

Description

Ford Motor Company is recalling certain model year 2001 through 2004 escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control cruise control is used.

Safety Risk

A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.

Remedy

Ford Motor Company has authorized your dealer to modify the engine cover to provide sufficient clearance for the speed control cable on your vehicle free of charge parts and labor. If you had the interim repair disconnect performed, the final repair will also reconnect the existing speed control cable.

Next Steps